干燥介質：
空氣適用物料：
多種可用看了XSG系列快速旋轉閃蒸干燥機的用戶又看了
留言詢價
虛擬號將在 180 秒后失效
使用微信掃碼撥號
XSG系類快速旋轉閃蒸干燥機
XSG系列旋轉閃蒸干燥機是我公司在引進吸收國外先進技術的基礎上，自行開發成功的新型干燥設備。該機技術先進，設計合理，結構緊湊，適用范圍廣，生產能力大，產品質量好，效率高，節能，在一個設備內干燥、粉碎、篩分一次完成，消除環境污染，整機性能達到國際**。閃蒸干燥機具有原來的軸承感應冷卻（水冷卻），設計用（油冷卻）油泵聯接送油潤滑、冷卻軸承，密封裝置性能優異，在主軸設計上采用半環式，電機利用調速電機，傳遞平穩、噪聲小，使用壽命是同類產品的10倍。XSG
series roating drier is developed by our company, and its techinology
is based on advance techinology adored.The machine is including many
superiority, such as reasonable design, compact stuction, widly
utilization, grrat productive capacity,good quality, high effect and
save energy, Drying, grinding and sieve are completed in one equipment
in once time.It eliminate pollution and the techinology is reached
international advance level.
-----------------------------------------------------------------------------------------------------------------
原理 Principle
熱空氣切線進去干燥器底部，在攪拌器帶動下形成強有力的旋轉風場。膏狀物料由螺旋加料器進入干燥器內，在高速旋轉攪拌槳的強烈作用下，物料受撞擊、摩擦及剪切力的作用下得到分散，塊狀物料迅速粉碎，與熱空氣充分接觸、受熱、干燥。脫水后的干物料隨熱氣流上升，分級環將大顆粒截留，小顆粒從環中心排出干燥器外，由旋風分離器和除塵器回收，未干透或大塊物料受離心力作用甩向器壁，重新落到底部被粉碎干燥。
The
hot air enters into the bottom of the drier in tangent direction. Under
the driving of the stirrer, a powerful rotating wind field is
formed.The paste state materials enter into the drier through the screw
charger. Under the powerful function of the stirring vanes at high-speed
rotation, the materials are distributed under the function of strike,
friction and shearing force. The block state mate-rials will soon be
smashed and contact the hot air fully and the materials are heated and
dried. The dried materials after the dewatering will g o up with the
heatair flow. The step rings will stop and keep the big particles. Small
particles will be discharged out of the drier from the ring center and
will be restored by the whirl separator and dust remover. The
not-fully-dried or big piece materials will be sent to the wall of the
equipment by centrifugal force function and be smashed again after they
fall down to the bottom.
典型用戶：
濰坊益康藥用化工廠 連云港市達歐化工有限公司 河南寶發醫藥化工有限公司
樂斯化學有限公司 西安惠豐藥業
-----------------------------------------------------------------------------------------------------------------
特點 Featrures
◎ 旋流、流化、噴動及粉碎分級技術的有機結合。
◎ 設備緊湊，體積小，生產效率高，連續生產，實現了“小設備，大生產”。
◎ 干燥強度大，能耗低，熱效率可達70%以上。
◎ 物料停留時間短，成品質量好，可用于熱敏性物料干燥。
◎ 負壓或微負壓操作，密閉性好，效率高，消除環境污染。
◎
The drying capacity for this machine is big but its energy consumption
is low. Its heat efficiency can go up to more than 70%.
◎ The
equipment is compact and small in size , high in production efficiency
and continuous in the production. It has realized that "a small
equipment can perform the large production".
◎ The material stay time
is very short. The quality of the final products is very good. The
machine can be used for drying the heat sensitive materials.
◎ For
the negative pressure or the micro-negative pressureoperation, the
machine is goog for its tightness and high in the efficiency so as to
eliminate the environmental pollution.
-----------------------------------------------------------------------------------------------------------------
結構示意圖 Schematic of structure
-----------------------------------------------------------------------------------------------------------------
技術參數 Technical parameters
型號
Type 筒體直徑(mm)
Barrel diameter 主機尺寸(mm)
Main machine dimensions 主機功率(kw)
Main machine power 處理風量(m3/h)
Treatment wind capacity 蒸發水量(kg/h)
Water evaporation quantity
XSG-2 200 250×2800 5-9 300-800 10-20
XSG-3 300 400×3300 8-15 600-1500 20-50
XSG-4 400 500×3500 10-17.5 1250-2500 25-70
XSG-5 500 600×4000 12-24 1500-4000 30-100
XSG-6 600 700×4200 20-29 2500-5000 40-200
XSG-8 800 900×4600 24-35 3000-8000 60-600
XSG-10 1000 1100×5000 40-62 5000-12500 100-1000
XSG-12 1200 1300×5200 50-89 10000-20000 150-1300
XSG-14 1400 1500×5400 60-105 14000-27000 200-1600
XSG-16 1600 1700×6000 70-135 18700-36000 250-2000
-----------------------------------------------------------------------------------------------------------------
結構示意圖 Schematic of structure
型號Type 高度(A)Height 長度(B)Length 寬度(C)Width
XSG-4 4600 5500 5000
XSG-6 5500 6550 6000
XSG-8 6000 7100 5600
XSG-10 7100 8200 6700
XSG-12 7500 8900 7000
XSG-14 7800 70580 8500
XSG-16 8500 14500 11000
-------------------------------------------------------------------------------------------------
技術參數 Technical parameters
物料名稱 進風溫度（℃） 初含濕量（%） 終含濕量（%） 實際干燥數據（kg 水/m3.h）
硬脂酸鋅 150 80 0.5 160-187
氫氧脂鋁 180 55 1.5 280-375
碳酸鋅 150 80 1.0 150-200
殺蟲丹 120 30 1.0 90-170
促進劑ZDC 150 60 0.5 104-110
TMTD 140 65 0.5 101-123
DSD酸 150 60 0.5 80-140
氧化鐵紅 200 60 0.5 336-365
三氧化銻 180 45 1.0 300-360
氯化亞銅 200 30 3.0 323-376
二氯異氰尿酸鈉 180 25 0.2-2 80-150
三氯異氰隸酸鈉 150 30 1.0 90-173
油溶黑 150 45 2.0 397-443
白碳黑 450 85 5.0 296-302
代酸錳鋅 120 30 1.0 105-186
酞青藍 150 55 1.0 170-206
檸檬酸鈣 140 40 1.0 400-552
超細碳酸鈣 160 70 1.5 470-512
泥漿處理劑 200 75 5.0 317-332
旋流、流化、噴動及粉碎分級技術的有機結合。設備緊湊，體積小，生產效率高，連續生產，實現了“小設備，大生產”。
XSG系列快速旋轉閃蒸干燥機的工作原理介紹？XSG系列快速旋轉閃蒸干燥機的使用方法？XSG系列快速旋轉閃蒸干燥機多少錢一臺？XSG系列快速旋轉閃蒸干燥機使用的注意事項XSG系列快速旋轉閃蒸干燥機的說明書有嗎？XSG系列快速旋轉閃蒸干燥機的操作規程有嗎？XSG系列快速旋轉閃蒸干燥機的報價含票含運費嗎？XSG系列快速旋轉閃蒸干燥機有現貨嗎？XSG系列快速旋轉閃蒸干燥機包安裝嗎？
手機版：
工商已核實
